Simulation and analysis on the motion characteristics of shock train under dynamic throttle
-
摘要: 为研究动态反压下的激波串特性,针对一种带凹腔的二元进气道/隔离段构型,在马赫数为6的来流下模拟了堵塞比从0.20增长到0.32再保持不变的动态节流流动,分析了堵塞比增长时间(1~10 ms)对激波串运动的影响。结果表明:激波串在节流变化初期向下游运动,随后向上游运动并最终稳定在某一位置。当堵塞比增长时间在5 ms以内时,激波串向下游和向上游运动的幅度分别为3 mm以内和约18 mm,且激波串运动滞后于节流变化,滞后时间随着增长时间的延长而缩短。当增长时间大于等于6 ms时,激波串可向下游运动到凹腔中部,幅度可达31 mm,并伴随着流动振荡;向上游运动幅度仍约为18 mm,激波串运动与节流变化近似同步。分析表明:较短增长时间工况下,激波串运动滞后主要是因为节流引起反压升高、传播时间大于堵塞比增长时间;较长增长时间工况下,凹腔内流动振荡主要是堵塞比增长初期凹腔亚声速区排出流量增加,回流区横向尺度减小,导致凹腔超声速区膨胀并出现“壅塞”,产生分离激波与回流区相互作用、发生振荡。工程设计时应考虑激波串运动的滞后及其对流动性能的影响。Abstract: To investigate the shock train characteristics under the influence of dynamic backpressure, the dynamic throttle flows of a two-dimensional inlet/isolator configuration were simulated under Mach 6 free steam condition, where the throttle ratio increased from 0.20 to 0.32 and were kept constant. The effects of increasing time (varied from 1–10 ms) of the throttle ratio were analyzed. The results show that the amplitudes of the shock train downstream motion and the upstream motion are within 3 mm and about 18 mm, respectively, as the throttle ratio increases from 0.20 to 0.32 within 5 ms. The shock train motion lag behind the throttle process and the lag time decreases with the prolongation of the throttle variation time. When the increasing time of the throttle ratio was 6 ms and above, the shock train could move downstream to the middle of the cavity and the motion amplitude reached 31 mm, accompanied by flow oscillations. The upstream motion amplitude of the shock train was still about 18 mm and the shock train motion was approximately synchronized with the throttle process. The analysis showes that the lag of the shock train motion is related to the time intervals of back pressure increment and propagation, which is longer than the variation time of the throttle ratio under the condition of short increasing time. Under the long increasing time conditions, the flow oscillations are related to the increase of the mass flowrate in the subsonic section of the cavity, which dominates the shrinkage of the recirculating region in the cavity. This further causes the expansion of the supersonic flows near the cavity and generates choked flows near the throttle region. Therefore, flow oscillations are generated through the interactions between the separated shock wave flows of the choked flows and the cavity recirculating region. The lag of the shock train motion and its influence on flow performance should be considered in engineering design.
-
Key words:
- scramjet engine /
- shock train /
- dynamic backpressure /
- hypersonic inlet /
- flow separation
-
表 1 CFD计算工况列表
Table 1. Conditions of CFD simulations
初始堵塞比 结束堵塞比 Δt /ms 0.20 0.32 1、2、4、5、6、8、10 表 2 自由来流参数
Table 2. Free stream airflow parameters
变量 参数 马赫数(Ma) 6 静压(p∞)/Pa 1050 静温(T∞)/K 115 速度(v∞)/(m·s−1) 1268 单位雷诺数Reunit/m−1 5.06 ×106 -
[1] ZARCHAN P. Scramjet Propulsion[M]. Reston: American Institute of Aeronautics and Astronautics, Inc, 2000: 369-446. [2] MATSUO K,MIYAZATO Y,KIM H D. Shock train and pseudo-shock phenomena in internal gas flows[J]. Progress in Aerospace Sciences,1999,35(1):33-100. doi: 10.1016/S0376-0421(98)00011-6 [3] FIÉVET R,KOO H,RAMAN V,et al. Numerical investigation of shock-train response to inflow boundary-layer variations[J]. AIAA Journal,2017,55(9):2888-2901. doi: 10.2514/1.j055333 [4] HUNT R L,GAMBA M. On the origin and propagation of perturbations that cause shock train inherent unsteadiness[J]. Journal of Fluid Mechanics,2019,861:815-859. doi: 10.1017/jfm.2018.927 [5] IM S,BACCARELLA D,MCGANN B,et al. Unstart phenomena induced by mass addition and heat release in a model scramjet[J]. Journal of Fluid Mechanics,2016,797:604-629. doi: 10.1017/jfm.2016.282 [6] LIN K C,JACKSON K,BEHDADNIA R,et al. Acoustic characterization of an ethylene-fueled scramjet combustor with a cavity flameholder[J]. Journal of Propulsion and Power,2010,26(6):1161-1170. doi: 10.2514/1.43338 [7] 黄河峡,谭慧俊,庄逸,等. 高超声速进气道/隔离段内流特性研究进展[J]. 推进技术,2018,39(10):2252-2273. doi: 10.13675/j.cnki.tjjs.2018.10.010HUANG H X,TAN H J,ZHUANG Y,et al. Progress in internal flow characteristics of hypersonic inlet/isolator[J]. Journal of Propulsion Technology,2018,39(10):2252-2273. doi: 10.13675/j.cnki.tjjs.2018.10.010 [8] HUNT R L,GAMBA M. Shock train unsteadiness characteristics,oblique-to-normal transition,and three-dimensional leading shock structure[J]. AIAA Journal,2017,56(4):1569-1587. doi: 10.2514/1.J056344 [9] 孔小平,陈植,张扣立,等. 隔离段激波串精细结构与压力特性实验研究[J]. 实验流体力学,2018,32(4):31-38. doi: 10.11729/syltlx20170178KONG X P,CHEN Z,ZHANG K L,et al. Experimental study on the fine structures and pressure characteristic of the shock train in the isolator[J]. Journal of Experiments in Fluid Mechanics,2018,32(4):31-38. doi: 10.11729/syltlx20170178 [10] LI Z F,GAO W Z,JIANG H L,et al. Unsteady behaviors of a hypersonic inlet caused by throttling in shock tunnel[J]. AIAA Journal,2013,51(10):2485-2492. doi: 10.2514/1.J052384 [11] 李一鸣,李祝飞,杨基明,等. 隔离段横向喷流作用下激波串运动特性研究[J]. 实验流体力学,2018,32(5):1-6. doi: 10.11729/syltlx20180023LI Y M,LI Z F,YANG J M,et al. Characteristics of the shock train motions caused by transverse injections into the isolator[J]. Journal of Experiments in Fluid Mechanics,2018,32(5):1-6. doi: 10.11729/syltlx20180023 [12] TAN H J,SUN S,HUANG H X. Behavior of shock trains in a hypersonic inlet/isolator model with complex background waves[J]. Experiments in Fluids,2012,53(6):1647-1661. doi: 10.1007/s00348-012-1386-1 [13] LI N,CHANG J T,XU K J,et al. Oscillation of the shock train in an isolator with incident shocks[J]. Physics of Fluids,2018,30(11):116102. doi: 10.1063/1.5053451 [14] LI N,CHANG J T,XU K J,et al. Instability of shock train behaviour with incident shocks[J]. Journal of Fluid Mechanics,2021,907:A40. doi: 10.1017/jfm.2020.702 [15] 徐珂靖,常军涛,李楠,等. 背景波系下的隔离段激波串运动特性及其流动机理研究进展[J]. 实验流体力学,2019,33(3):31-42. doi: 10.11729/syltlx20180196XU K J,CHANG J T,LI N,et al. Recent research progress on motion characteristics and flow mechanism of shock train in an isolator with background waves[J]. Journal of Experiments in Fluid Mechanics,2019,33(3):31-42. doi: 10.11729/syltlx20180196 [16] XIONG B,FAN X Q,WANG Y,et al. Experimental study on self-excited and forced oscillations of an oblique shock train[J]. Journal of Spacecraft and Rockets,2018,55(3):640-647. doi: 10.2514/1.A33973 [17] XIONG B,FAN X Q,WANG Z G,et al. Analysis and modelling of unsteady shock train motions[J]. Journal of Fluid Mechanics,2018,846:240-262. doi: 10.1017/jfm.2018.209 [18] 李季,罗佳茂,杨顺华. 边界层抽吸和脉动反压作用下隔离段内流动特性研究[J]. 推进技术,2019,40(8):1759-1766. doi: 10.13675/j.cnki.tjjs.180498LI J,LUO J M,YANG S H. A study of flow characteristics in isolator with effects of boundary layer suction and oscillating back pressure[J]. Journal of Propulsion Technology,2019,40(8):1759-1766. doi: 10.13675/j.cnki.tjjs.180498 [19] WANG C P,CHENG C,CHENG K M,et al. Unsteady behavior of oblique shock train and boundary layer interactions[J]. Aerospace Science and Technology,2018,79:212-222. doi: 10.1016/j.ast.2018.05.054 [20] CHENG C,WANG C P,CHENG K M. Response of an oblique shock train to downstream periodic pressure perturbations[J]. Proceedings of the Institution of Mechanical Engineers, Part G:Journal of Aerospace Engineering,2019,233(1):57-70. doi: 10.1177/0954410017727028 [21] SU W Y,JI Y X,CHEN Y. Effects of dynamic backpressure on pseudoshock oscillations in scramjet inlet-isolator[J]. Journal of Propulsion and Power,2016,32(2):516-528. doi: 10.2514/1.B35898 [22] 高文智, 赵鹏飞, 宁重阳, 等. 周期节流扰动下激波串振荡流动的数值模拟 [J/OL]. 航空动力学报, [2022-02-25].https://kns.cnki.net/kcms/detail/detail.aspx?dbcode=CAPJ&dbname=CAPJLAST&filename=HKDI20220119008&uniplatform=NZKPT&v=QYhreWw4sfPVim7zEs3we1sM-BW17MsMxVn4xtBcnssXFmzPnPnzekfU643sZhmCdoi: 10.13224/ j.cnki.jasp.20210524. [23] NIE B P, LI Z F, HUANG R, et al. Effect of boundary layer suction on shock train oscillations in an inlet/isolator model[C]//Proceedings of the 32nd International Symposium on Shock Waves (ISSW32 2019), Singapore: Research Publishing Services. 2019. doi: 10.3850/978-981-11-2730-4_0155-cd [24] GAO W Z,CHEN J,LIU C H,et al. Effects of vortex generators on unsteady unstarted flows of an axisymmetric inlet with nose bluntness[J]. Aerospace Science and Technology,2020,104:106021. doi: 10.1016/j.ast.2020.106021